Change Over to LoRa for Telemetry

Change Over to LoRa Radio for Telemetry

The Telemetry Radio used onboard Voyager 2.0 for the past few years has been the standard 433Mhz APM Telemetry Radio.

It operates well over short distances of a few hundred metres, as a transparent full duplex serial link, with a default transmission rate of 57600 Baud.

Traditional APM Telemetry Radio

The design of the telemetry system was that the vessel would constantly broadcast telemetry messages, whether they were being received or not.

The specific messages being broadcast are enabled by bit mask.

The mission definition does support power control where the telemetry radio can be powered off or on during specific mission steps.

The problem with the standard low cost telemetry radio is that distance is very limited. More efficient antennas were used to extend the range to a few hundred metres, but the link was always marginal at that distance.

LoRa Radio

LoRa (Long Range) Radio offers long range communications up to several kilometers with line of sight. 

LoRa is proprietary technology developed by Semtech, who provide a range of transceiver chips, primarily the SX1278. Many PCB modules are available from multiple suppliers using the SX1278 device.

The module used here is the Ebyte 433MHz E32-433T20DT 100mW.

Ebyte 433MHz LoRa Radio

The Ebyte module incorporates additional microprocessing components in order to provide a serial interface, making it reasonably simple to incorporate into the existing Voyager Controller design.

Ebyte Modules mounted for use with USB for the Voyager Base Station and a Serial Connection for use onboard.

The Ebyte LoRa module uses an effective transmission rate of approximately 2400 Baud. It can be increased, but that is at the cost of reduced range. The default rates are being used here.

The design of the telemetry system has been changed to a "request" system, rather than a broadcast system. This means that the vessel remains mostly silent and only transmits telemetry messages in response to specific requests from the Voyager Base Station.

Hence the scheduling of telemetry messages is dictated by the Base Station.

This alleviates the need to consider power control for the Telemetry Radio on board the vessel, because it will only transmit on demand.

The main aim of changing to LoRa Radio is to gain increased range for telemetry and control of the vessel. This should allow faster reconfiguration and testing of the Wingsail and the vessel, without the need to keep returning to shore.

Note: This is part of the ongoing development of a low cost autonomous oceangoing sailing drones, utilising a self-trimming wingsail. This is the Voyager series of sailing drones.